B-10 Mobile LEDInstallation & maintenance manualR9855510R5976956/0319/06/2007
1. Safety instructionsWhat is a faulty operation• Levelling the trailer by first placing the rear stabilizers. This way almost the half of the weight
1. Safety instructionsThe good way of w orking, building off the vehicle• Retract the rear stabilizers first and then the front stabilizers till none
1. Safety instructions8 R5976956 B-10 MOBILE LED 19/06/2007
2. System Overview2. SYSTEM OVERVIEWOverview• Introduction• B-10 Mobile LED tiles•LEDPro• B-10 Mobile LED trailer• B-10 Mobile LED generator2.1 I ntro
2. System OverviewImage 2-2All tiles are connected in series via a data path. Each tile picks out a part of the video information of the data stream o
2. System OverviewD320 input compatibilityS-Video, Composite, YUV, RGB, SDI, HDSDI, Data DVI up to UXGACertifications ETL,CE,CEBEC,TUV,FCCclassATile d
2. System OverviewBCADEImage 2-4SLite input/output ports.A Connection module.B Power input port.C Power output port.D Data input port.E Data output po
2. System OverviewImage 2-6LEDPRo2.3.2 LED-PRo featuresOverview• Three universal inputs accept RGBHV/RGBCs/RGsB computer video, component video (STD o
2. System Overview2.4.2 DimensionsOverview424021122500238526883584Image 2-7Dimensions2.5 B-10 Mobile LED generator2.5.1 IntroductionOverviewPlease rea
2. System Overview2.5.2 ComponentsOverview• Type: EPS183TDE• Power: 3 x 400V : 18kVA, 1 x 230V : 6kVA• Alternator: Leroy Somer LSA37M8 with AVR (brush
Barco nv EventsNoordlaan 5, B-8520 KuurnePhone: +32 56.36.89.70Fax: +32 56.36.88.24E-mail:[email protected] us at the web: www.barco.comPrin
2. System Overview2.5.3 Control panelDescriptionImage 2-9Control panelThe control panel of the EPS8DE consists of:• Starting key (off / on / glow / st
2. System OverviewOn the inside of the control panel there can be found:• 2 x relay 12V/30A for guarding oil pressure and temperature of cooling liqui
2. System OverviewImage 2-13Identification2. In case of overload, the thermal-magnetic protection in the control panel shall be switched off after a s
2. System OverviewImage 2-15AlternatorThermal-magnetic protection and earth leakage protection (with earth pin).Image 2-162.5.8 MaintenanceOverviewAll
2. System Overview2Fuel filter D1105/V1505398111105 FF 5226 15221430803In line filter D1105/V1505130000016 FF 149 1281430124Air filter cartridge1105/V
3. Setup of the B-10 Mobile LED3. SETUP OF THE B-10 MOBILE LEDOverview• Installation of the B-10 Mobile LED• Powering the B-10 Mobile LED• Extending t
3. Setup of the B-10 Mobile LEDImage 3-2Contact key and power cable of pump2. After several seconds turn-on the generator with this contact key.Cautio
3. Setup of the B-10 Mobile LEDImage 3-3Pump system2. Push on the black button.3. Lift the first halve of the LED-wall by using the leverLift this par
3. Setup of the B-10 Mobile LEDImage 3-5Safety piecesCaution: Make sure the safety pins are placed in the mast. This is mandatory for security reason
3. Setup of the B-10 Mobile LEDHow to move down?1. Lift down the display till it’s on the bottom.Note: Do not forget to take away the safety pieces fr
ChangesBarco provides this manual ’as is’ without warranty of any kind, either expressed or implied, including but not limited to the implied war-rant
3. Setup of the B-10 Mobile LED26 R5976956 B-10 MOBILE LED 19/06/2007
4. Maintenance, Service4. MAINTENANCE, SERVICEOverviewFor maintenance, service and repair on the B-10 Mobile LED please consult qualified service tech
4. Maintenance, ServiceDaily 500 kmQuarterlyYearlyCLTCl CLTCl CLTCl CLTClLight coverOutriggersFunctioningAttachmentFrame Transverse at side sectionsup
4. Maintenance, ServiceDaily 500 kmQuarterlyYearlyCLTCl CLTCl CLTCl CLTClcylinder flexibleattachment to gridGeneratorgeneralmotoralternatoroilgas - di
4. Maintenance, ServiceService intervalsFor a detailed explanation of the service intervals, consult the service and maintenance manual of the generat
4. Maintenance, ServiceOverview service centerFor EuropeCountry Engine (Kubota) Alternator (Leroy Somer)AustriaMAG Motoren GmbHA-5023 SalzburgTel. 43.
4. Maintenance, ServiceCountry Engine (Kubota) Alternator (Leroy Somer)MaltaGaetano Caruana LimitedZebbug, MALTA G.C.Tel. 356.460881Fax. 356.465824Net
4. Maintenance, ServiceCountry Engine (Kubota) Alternator (Leroy Somer)Brazil Polus Maquina EletricasCampuci Sao Paulo CEP 01524Tel. 55.11.9148766Chil
4. Maintenance, ServiceCountry Engine (Kubota) Alternator (Leroy Somer)IsraelFK Generators & Equipm.Ind. Z. Holon PB 1729Tel. 972.3.5570567Fax. 97
4. Maintenance, ServiceCountry Engine (Kubota) Alternator (Leroy Somer)Turkey AltinbogaIstanbulTel. 90.212.5013465Fax. 90.212.6122381SASIM Kemeralti80
4. Maintenance, ServiceCountry Engine (Kubota) Alternator (Leroy Somer)Guinea Les ateliers de GuineeConakryTel. 224.464744Ivory Coast SorepelAbidjan 0
A. Drawings B10 trailerA. DRAWINGS B10 TRAILERA.1 Electrical drawingsOverviewImage A-1R5976956 B-10 MOBILE LED 19/06/2007 37
A. Drawings B10 trailerImage A-238 R5976956 B-10 MOBILE LED 19/06/2007
A. Drawings B10 trailerImage A-3R5976956 B-10 MOBILE LED 19/06/2007 39
A. Drawings B10 trailerImage A-440 R5976956 B-10 MOBILE LED 19/06/2007
A. Drawings B10 trailerImage A-5R5976956 B-10 MOBILE LED 19/06/2007 41
A. Drawings B10 trailer42 R5976956 B-10 MOBILE LED 19/06/2007
Revision SheetTo:Barco nv Events/Docu m entationNoordlaan 5, B-8520 KuurnePhone: +32 56.36.89.70, Fax: +32 56.36.88.24E-mail: [email protected], W
Table of contentsTABLE OF CONTENTS1. Safety instructions ...
Table of contents2 R5976956 B-10 MOBILE LED 19/06/2007
1. Safety instructions1. SAFETY INSTRUCTIONSOverview• General instructions• Important Safety instructions• Safety instructions for LED screen setup• S
1. Safety instructions1.2 Important Safety instructionsInstructions:• Read these instructions.• Keep these instructions.• Heed all warnings.• Follow a
1. Safety instructions1.5 Important WarningsImportant warnings• High leakag e current:The combination of multiple tiles in an installation results in
Comentarios a estos manuales